D ATA S H E E T J305E-AC

MODEL J305E-AC with Bayonet Cap

VOLTAGE 6
MATERIAL Polypropylene
DIMENSIONS Inches (mm)
BATTERY Deep-Cycle Flooded/Wet Lead-Acid Battery
COLOR Maroon
WATERING HydroLink™ Watering System

PRODUCT + PHYSICAL SPECIFICATIONS

BCI Group Size Type Terminal Type G Dimensions C Inches (mm) Weight Lbs. (kg)
Length Width F
Height

902 J305E-AC 7 12.17 (309) 6.85 (174) 14.41 (366) 83 (38)

ELECTRICAL SPECIFICATIONS
Cranking Performance Capacity A Minutes Capacity B Amp-Hours (AH) Energy (kWh) Internal Resistance (mΩ) Short Circuit Current (amps)
D E
C.C.A. @ 0°F (-18°C) C.A. @ 32°F (0°C) @ 25 Amps @ 75 Amps 5-Hr 10-Hr 20-Hr 100-Hr 100-Hr
— —
— — 645 160 250 280 305 339 2.03

CHARGING INSTRUCTIONS
Charger Voltage Settings (at 77°F/25°C)

System Voltage 6V 12V 24V 36V 48V

Bulk Charge 7.4 14.8 29.6 44.5 59.3

Float Charge 6.7 13.5 27.0 40.5 54.0

Equalize Charge 8.1 16.2 32.4 48.6 64.8

Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under or overcharging will damage the battery and shorten its life as with any battery.

CHARGING TEMPERATURE COMPENSATION STATE OF CHARGE MEASURE OF OPEN-CIRCUIT VOLTAGE

Add Subtract Percentage Charge Specific Gravity Cell 6 Volt
100 1.277 2.122 6.37
0.005 volt per cell for every 1°C below 25°C 0.005 volt per cell for every 1°C above 25°C
0.0028 volt per cell for every 1°F below 77°F 0.0028 volt per cell for every 1°F above 77°F 90 1.258 2.103 6.31
80 1.238 2.083 6.25
70 1.217 2.062 6.19
OPERATIONAL DATA
60 1.195 2.040 6.12
Operating Temperature Self Discharge
50 1.172 2.017 6.05
-4°F to 113°F (-20°C to +45°C). At 40 1.148 1.993 5.98
5 – 15% per month depending on storage
temperatures below 32°F (0°C) maintain a
temperature conditions. 30 1.124 1.969 5.91
state of charge greater than 60%.
20 1.098 1.943 5.83
10 1.073 1.918 5.75

Designed in compliance with applicable BCI, DIN, BS and IEC standards.

Tested in compliance to BCI and IEC standards.
 G
TERMINAL CONFIGURATIONS
7 UT Universal Terminal

Terminal Height Inches (mm)

1.10 (28)
Torque Values in-lb (Nm)
95 – 105 (11 – 12)
Bolt
5/16”

BATTERY DIMENSIONS (shown with UT)

12.17 (309)
LENGTH

14.41 (366)
HEIGHT

6.85 (174) 13.29 (338)

WIDTH

TROJAN J305E-AC PERFORMANCE PERCENT CAPACITY VS. TEMPERATURE

1000 140 60

Estimation Purposes Only 120 50

100 40

30
100 80
Discharge Current (amps)

20

Temperature (C)
Temperature (F)

60

10
40
0
10 20
-10
0
-20

-20
-30

1 -40 -40
10 100 1000 10000 100000
0% 20% 40% 60% 80% 100% 120%

Time (mins) Percent of Available Capacity

A. The number of minutes a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above D. C.C.A. (Cold Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 0°F
1.75 V/cell. Capacities are based on peak performance. (-18°C) at a voltage above 1.2 V/cell.
B. The amount of amp-hours (AH) a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage E. C.A. (Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 32°F (0°C)
above 1.75 V/cell. Capacities are based on peak performance. at a voltage above 1.2 V/cell. This is sometimes referred to as marine cranking amps @ 32°F or M.C.A. @ 32°F.
C. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing F. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
minimum. G. Terminal images are representative only.

800.423.6569 / +1.562.236.3000 / trojanbattery.com J305E-AC DS 2016_0502

© 2016 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this
publication at any time, without notice or obligation.