DATA SHEET MOTIVE 24TMX

MODEL 24TMX with POD vent

VOLTAGE 12
MATERIAL Polypropylene
DIMENSIONS Inches (mm)
BATTERY Deep-Cycle Flooded/Wet Lead-Acid Battery
COLOR Maroon
WATERING No Watering System Available

12 VOLT
PHYSICAL SPECIFICATIONS
BCI MODEL NAME VOLTAGE CELL(S) TERMINAL TYPE G DIMENSIONS C INCHES (mm) WEIGHT H LBS. (kg)

LENGTH WIDTH HEIGHT F

24 24TMX 12 6 7, 8, 9, 16 47 (21)
10.92 (277) 6.62 (168) 9.25 (235)

ELECTRICAL SPECIFICATIONS
CRANKING PERFORMANCE CAPACITY A MINUTES CAPACITY B AMP-HOURS (Ah) ENERGY (kWh) INTERNAL RESISTANCE (mΩ) SHORT CIRCUIT CURRENT (amps)

C.C.A. @ 0°F (-18°C) C.A. @ 32°F (0°C)

D E
@ 25 Amps @ 75 Amps 5-Hr 10-Hr 20-Hr 100-Hr 100-Hr
— —
— — 140 36 70 78 85 94 1.13

CHARGING INSTRUCTIONS CHARGING TEMPERATURE COMPENSATION

CHARGER VOLTAGE SETTINGS (AT 77°F/25°C) ADD SUBTRACT

SYSTEM VOLTAGE 12V 24V 36V 48V 0.005 volt per cell for every 1°C below 25°C 0.005 volt per cell for every 1°C above 25°C
0.0028 volt per cell for every 1°F below 77°F 0.0028 volt per cell for every 1°F above 77°F
Bulk Charge 14.82 29.64 44.46 59.28

Float Charge 13.50 27.00 40.50 54.00 OPERATIONAL DATA

Equalize Charge 16.20 32.40 48.60 64.80 OPERATING TEMPERATURE SELF DISCHARGE

-4°F to 113°F (-20°C to +45°C). At

Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under or 5 – 15% per month depending on storage
temperatures below 32°F (0°C) maintain a
overcharging will damage the battery and shorten its life as with any battery. temperature conditions.
state of charge greater than 60%.

RECYCLE RESPONSIBLY STATE OF CHARGE MEASURE OF OPEN-CIRCUIT VOLTAGE

PERCENTAGE CHARGE SPECIFIC GRAVITY CELL 12 VOLT

100 1.277 2.122 12.73

12V
Flooded 90 1.258 2.103 12.62
80 1.238 2.083 12.50
70 1.217 2.062 12.37
60 1.195 2.040 12.24
50 1.172 2.017 12.10
40 1.148 1.993 11.96
30 1.124 1.969 11.81
20 1.098 1.943 11.66
10 1.073 1.918 11.51
 TROJAN 24TMX PERFORMANCE PERCENT CAPACITY VS. TEMPERATURE

1000 140 60

120 50

40
100
Estimation Purposes Only 30
100
Discharge Current (amps)

80

(F)

Temperature(C)
(C)
Temperature (F)
20

Temperature
60

Temperature
10
40
0
10 20
-10

0
-20

-20 -30

1 -40 -40
10 100 1000 10000 0% 20% 40% 60% 80% 100% 120%

Time (mins) Percentof

Percent of Available
Available Capacity
Capacity

BATTERY DIMENSIONS (shown with WNT)

10.92 (277) 10.92 (277) 10.92 (277)
LENGTH LENGTH LENGTH

9.25 (235) 9.25 (235)

HEIGHT HEIGHT
8.16 8.16
(207) (207)

6.62 (168) 6.62 (168)

WIDTH WIDTH
TERMINAL CONFIGURATIONSG
7 UT UNIVERSAL TERMINAL 8 AP AUTOMOTIVE POST TERMINAL

Terminal Height Inches (mm)

1.10 (28) Terminal Height Inches (mm)
Torque Values in-lb (Nm) 0.83 (21)
95 – 105 (11 – 12) Torque Values in-lb (Nm)
Bolt 50 – 70 (6 – 8)
5/16”

9 WNT WINGNUT TERMINAL 16 SLT SMALL L-TERMINAL

Terminal Height Inches (mm) Terminal Height Inches (mm)

1.50 (38) 1.31 (33)
Torque Values in-lb (Nm) Torque Values in-lb (Nm)
95 – 105 (11 – 12) 95 – 105 (11 – 12)
Bolt Bolt
5/16” 5/16”

A. The number of minutes a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above E. C
 .A. (Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 32°F (0°C) at a voltage above
1.75 V/cell. Capacities are based on peak performance. 1.2 V/cell. This is sometimes referred to as marine cranking amps @ 32°F or M.C.A. @ 32°F.
B. The amount of amp-hours (AH) a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell. F. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
Capacities are based on peak performance. G. Terminal images are representative only.
C. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing minimum. H. Weight may vary.
D. C.C.A. (Cold Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 0°F (-18°C) at a voltage
above 1.2 V/cell.

TROJAN BATTERY
COMPANY WITH
QUALITY SYSTEM
Designed in compliance with applicable BCI, DIN, BS and IEC standards.
CERTIFIED BY DNV
= ISO 9001:2015 =
Tested in compliance to BCI and IEC standards.

800.423.6569 / +1.562.236.3000 / trojanbattery.com 24TMX.DS_020819

© 2019 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted
from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this publication at any time, without notice or obligation.