Nitoproof 10: Constructive Solutions
Nitoproof 10: Constructive Solutions
Nitoproof 10: Constructive Solutions
Uses Properties
To act as a damp-proof membrane and vapour seal for The essential properties of Nitoproof 10 are:
concrete and masonry. It can also be used as a protective
coating for concrete below ground. Bitumen content: 60%
Time between coats: Minimum 2 hours
Foundation protective coating
Chemical resistance
Curing membrane (Test results with some common chemicals)
Potable water: Excellent
Sea water: Excellent
Advantages 10% Sodium Hydroxide: Satisfactory
5% Sodium sulphate: Satisfactory
Nitoproof 10 has a number of significant advantages as 0
Wet heat (70 C + 80% R.H.): Satisfactory
follows:
Instructions for Use
Easy to apply
Surface preparation
Economical in use
Surfaces to be coated must be sound, clean and free of oil
Multipurpose, serves both as a protective coating and or grease. Any oil or grease contamination should be
curing membrane removed with a proprietary chemical degreaser. If the
surface is dusty, it should be primed with a coat of Nitoproof
Contains no solvent, no health hazard 10, diluted with an equal quantity of cool, clean water and
allowed to dry.
Resists attack by chloride and sulphate ions present in
the ground water Application
Cleaning
Standards compliance
Nitoproof 10 should be removed from tools and equipment
Nitoproof 10 complies with concrete curing requirements of with water when it is wet. On drying Nitoproof 10 may be
ASTM C309-93 when applied at a rate of 2m2 per litre and to removed with Fosroc Solvent 102.
BS6949:1991 requirements for bituminous coating.
Technical support
Specification
Fosroc offers a full technical support package to specifiers,
Concrete surfaces shall be waterproofed with Nitoproof 10, a end users and contractors, as well as on-site assistance in
bitumen emulsion protective coating. It shall be applied at a locations all over the world.
rate of 2 m2 per litre, and thus act as a combined
waterproofing and curing agent in accordance with ASTM
C309.
Page 1
Nitoproof 10
Estimating Additional Information
The coverage will vary upon the level of protection required: Cementitious & epoxy grouts
Fire
Flash point
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com Khamis Mushayt Tel: (07) 250 0469 Fax: (07) 250 0469 CSD Tel: (02) 608 0999 Fax: (02) 638 0693
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2 FO SA/NITOPROOF 10/05/A
SAFETY DATA SHEET
1: IDENTIFICATION OF THE SUBSTANCE / PREPARATION AND OF THE COMPANY /
UNDERTAKING
Product Name: NITOPROOF 10
Application: Waterproofing coating / membrane
Company: Fosam Comapny Limited
Address: Jeddah Industrial Area, Phase 4, Road 414, Street 407, P.O. Box 11081, Jeddah
Telephone: (02) 637 5345 (4 Lines) Fax (02) 637 5891
2: COMPOSITION/INFORMATION ON INGREDIENTS
Composition: Bitumen, Water
Hazardous Ingredient (s) Risk Phrases (see Section 11) Other Inf. Cas No. 64742-93-4 > 50%
All constituents of this product are listed in EINECS (European Inventory of Existing Commercial Chemical Substances)
or ELINCS (European List of New Chemical Substances) or are exempt.
Refer to Section 8 for Occupational Exposure Limits.
3: HAZARDS IDENTIFICATION
Long term skin contact may cause health problems.
4: FIRST AID MEASURES
Eyes: Irrigate immediately with copious quantities of water for several minutes. Obtain medical attention if
irritation persists.
Skin: Wash thoroughly with soap and water or suitable skin cleanser as soon as possible.
Inhalation: Remove from exposure - unlikely to occur.
Ingestion: Wash out mouth with water. Obtain medical attention.
Nitoproof10
Section A : General Comments
l Comments
High temperature working
It is suggested that, for temperatures above 350C, the following guidelines are adopted as good
working practice:
(i) Store unmixed materials in a cool (preferably temperature controlled) environment, avoiding
exposure to direct sunlight.
(ii) Keep equipment cool, arranging shade protection if necessary. It is especially important to
keep cool those surfaces of the equipment which will come into direct contact with the material
itself.
(iii) Try to avoid application during the hottest times of the day, arrange temporary shading as
necessary.
(iv) Make sufficient material, plant and labour available to ensure that application is a continuous
process.
Equipment
Fosroc operates a policy to encourage the use, where possible, of approved or licensed applicators.
This ensures that repairs are completed satisfactorily so that the long term performance of the
materials is assured. For contractors who wish to apply the materials themselves Fosroc is also able
to offer technical assistance and training, either on-site or at its Training Centre in Jeddah.
www.fosroc.com
constructive solutions
1.0 Preparation
1.1 Clean the surface free of oil, grease and all loosely adhering particles, by stiff wire brushing.
1.2 Follow step 1 by soft brushing and blowing of dry, oil-free compressed air.
1.3 Ensure that the surface is free of surface water or bleeding. Conduct a test patch when
there is a doubt of the substrate condition.
2.0 Application
2.2 Apply a full coat of Nitoproof 10, using a brush, roller or spray equipment. Confirm coverage
rates from the relevant technical data sheet and apply accordingly.
2.3 Apply the second coat at right angle to the first, after the first coat has dried fully.
2.4 Clean grit of 2mm size should be broadcast into the wet second coat to provide the
mechanical key, when it is necessary to cover the membrane with a screed or render.
2.6 Damaged areas of Nitoproof 10 can be readily over coated to restore the continuity of the
membrane.
3.0 Cleaning
3.1 Clean all tools and equipment with Fosroc Solvent 102.
This method statement is offered by Fosroc as a ‘standard proposal’ for the application of Nitoproof
10. It remains the responsibility of the Engineer to determine the correct method for any given
application.
Where alternative methods are to be used, these must be submitted to Fosroc for approval, in
writing, prior to commencement of any work. Fosroc will not accept responsibility or liability for
variations to the above method statement under any other condition.
Page 2 of 2
Job References for Nitoproof 10 (Fosroc Saudi Arabia)
sorted by ascending Project Category and ascending Project Date
Main Contractor, Project
Project Category Project Title, (Client) Product Application Quantity Site Location (Subcontractor) Specifier/ Consultant Date
Building- Commercial- Huyandai Showroom, Water proofing 1000 Litre(s) Hasa Tareg Al Jafari Hyundai Majdoii May-10
Office (Hyundai Majdoii) Cont.
Building- Commercial- Building of Ministry of water proof 4000 Litre(s) Madinah Al Dar AL Zahbia Al Outashan Jul-10
Office Commerce, (Ministry Of
Commerce)
Building- Commercial- Al Andaluse Mall, (Al Habib 1 50 200 L Jeddah Mubark Al-Guthmi Sep-07
Shops Group) Drum
Building- Education- King Saud University - Girl, water proofing 600 Litre(s) Hassa Abdullah Al Khoradi Imar May-08
College (KFU)
Building- Education- KFU - Girls College of Anchroing,grout,Water 2200 Litre(s) Hofuf Abdullah Al Khudari Jul-09
College Sceince B 02, (KFU) Proofing
Building- Education- KFU-Computer college Water Proofing 600 Litre(s) Hofuf Abdullah Al Khodari Imaar Eng. Office Sep-09
College B01, (KFU)
Building- Education- KFU - Girls Educational water 4600 Litre(s) Al Hasa Abdullah Al Khodari Imaar Eng. Office Nov-09
College Collage - B32, (KFU) Proofing,Grout,Adhesive,
Concrete Repair
Building- Education- KFU - Female Computer water Proofing 2600 Litre(s) Al Hasa Abdullah Al Khodari Imaar Eng. Office Nov-09
College Scince Collage - B01,
(KFU)
Building- Education- KFU - Infra Structure Ph Water 3000 Litre(s) Hasa FEMCO Zuhair Fayez Jan-07
University 3,4, (KFU) Proofing,Grout,Coating
Building- Education- KFU-Infrastructure waterproofing, repair, 200 Litre(s) Hoffuf Al Arrab Zuhair Fayes Feb-07
University Phase#2, (Ministry of sealants and concrete
Education) curing
Building- Education- KFU-Infrastructure water proofing/concrete 200 Litre(s) Hassa Al Arrab Zuhair Fayes May-07
University Phase#2, (KFU) repair/adhesive/surface
treatment
Building- Education- KFU - Infar Structure # 2, repair,Surface 200 Litre(s) Hofuf Al Arrab Contraction Al Naeem Architect Eng. Jun-07
University (KFU) Treatment,Water Company
Proofing,Anchroing,coatin
g,grout
Building- Education- KFU- Infra Structure Water Proofing,Surface 400 Litre(s) Hofuf Al Arrab Contracting Zuhair Fayez Sep-07
University project Phase# 2, (KFU) Treatment,Concrete Company
Repair,Adhesive,Sealant,
Anchroing
Building- Education- King Saud University - Adhesive,Surface 48 drums Riyadh SBG - PBAD Saud Consult Jan-08
University Girls, (Ministry of High Treatment,Concrete
Eduacation) Repair,Waterproofing
Building- Education- King Saud Medical achoring, sealant, 1200 Litre(s) Al Hassa Saudi Bin Laden Sami Al Khatlan Feb-08
University University, (Ministry of waterproofing, repair,
Education)
Building- Education- KFU - Infar Structure # 3,4, Water 2000 Litre(s) Hofuf FEMCO Zuhair Fayez Jun-08
University (KFU) Proofing,Admixtures.
26/01/2011 Page 1 of 4
Building- Education- KFU ph # 3 & 4, (KFU) repair,Admixtures,Surface 2000 Litre(s) Hofuf FEMCO Zuhair Fayez Jul-08
University Treatment,Water Proofing
Building- Education- KFU ph # 3 & 4, (KFU) Water Proofing,repair 600 Litre(s) Hofuf FEMCO, (Saudi Zuhair Fayez Jul-08
University Anthos)
Building- Education- KSU, (National Guerd) Anchroing,grout,Surface 1600 Litre(s) Mubarraz Saudi Bin Laden Dar Al Handasah Jul-08
University Treatment,Water Proofing ABCD, (Saudi Bin
Laden RPD)
Building- Education- KFU - Infar Structure # 3,4, Water 2000 Litre(s) Hofuf FEMCO Zuhair Fayez Jul-08
University (KFU) Proofing,Admixtures.
Building- Education- KFU- Infra Structure Waterproofing 1600 Litre(s) Hofuf FEMCO, (Saudi Zuhair Fayez Sep-08
University Project Ph#3 & 4, (KFU) Anthos)
Building- Education- King Saud University - Concrete 82 drums Riyadh SBG - PBAD Saud Consult Dec-08
University Girls, (Ministry of High Repair,Waterproofing,Adh
Eduacation) esive
Building- Education- King Saud University - Adhesive,Grout & 37 drum Riyadh SBG - PBAD Saud Consult Dec-08
University Girls, (Ministry of High Anchor,Surface
Eduacation) Treatment,Concrete
Repair,Waterproofing
Building- Education- KFU - Girls Computer Water Proofing 600 Litre(s) Hofuf Abdullah Al Khudari Jul-09
University Sceince College B 01,
(KFU)
Building- Education- KSU Project, (KSU) Grout,Water Proofing 400 Litre(s) Hofuf Saudi Binladin Dar Al Handasah Sep-09
University ABCD, (Saudi
Binladin RPD)
Building- Education- Princess Noura University, Damp Proofing,Curing 15 drum Riyadh SBG, (Freyssinet) Dar AL Handassah Oct-09
University (Ministry of High Compound
Eduacation)
Building- Education- Princess Noura University, Anchoring,Waterstop,Tie 40 drums Riyadh SBG, (AXAL Arabia) Dar AL Handassah Nov-09
University (Ministry of High Rod,Curing
Eduacation) Compound,Damp
Proofing,Release
agent,Concrete Repair
Building- Education- KFU - Infra sturcture - Sealant,water 400 Litre(s) Al Hasa Al Arrab( KFU- Zuhair Fayez Nov-09
University Phase# 2, (KFU) Proofing,Coating,Concret PH#2)
e Repair
Building- Education- KFU - Infra Stucture Ph water Proofing 1000 Litre(s) Al Hasa FEMCO Zuhair Fayez Nov-09
University 3,4, (KFU)
Building- Education- Faculty Of science - Tibah Waterproof for concrete 8000 Madinah Al Khodarie Co Al Oteshan Dec-09
University University, (Ministry Of under ground,Repair Kilogram(s)
Education) flooring
Building- Education- King Saud University - Concrete 30 drums Riyadh SBG - PBAD Saud Consult Aug-10
University Girls, (Ministry of High Repair,Waterproofing,Adh
Eduacation) esive
Building- Education- King Saud University - Adhesive,Flooring,Surfac 40 drums Riyadh SBG - PBAD Saud Consult Oct-10
University Girls, (Ministry of High e Treatment,Concrete
Eduacation) Repair,Waterproofing,Gro
ut & Anchor
26/01/2011 Page 2 of 4
Building- Housing- Mina Retaining Wall / Concrete 12000 Makkah Artec Company Dar AL Handasa Sep-00
Communal Makkah, (Ministry Of Public Admixtures&Waterproofin Litre(s) (Arabian Technical
Works) g to Retaining Wall Contracting Co. )
Building- Housing- Ministry of Interior - Waterproofing, Curing 2 drum Dammam Saudi Binladen Dar Al-Riyadh Consultants Jun-06
Prisons Dammam Jail, (Ministry of Compound, Additives and Group, (Peaks
Interior) Repair Contracting)
Building- Industrial- Unicoil Expansion, (Unicoil) Foundation Coating 1680 Litre(s) Jubail Dyweidag S.A., Saudi Daneilli Sep-04
Factory (N/A)
Building- Industrial- EPCC, (Epcc) Waterproofing, 5400 Litre(s) Dammam Gama Industry Atkins May-05
Factory Repair,Curing,Shuttering
& Grouting
Building- Industrial- Dammam Cement Factory Waterproofing, Repair, 5400 Litre(s) North Dammam Gama Industry, Alkins Oct-05
Factory (E.P.C.C.), (Dammam Curing, Shuttering and (N/A)
Cement Factory Grouting
(E.P.C.C.))
Building- Industrial- Saudi Paper Mill, (Saudi Grout, Waterproofing and 4 drum Dammam Asharq Al-Baeid, Saudi Paper Mill Apr-06
Factory Paper Mill) Flooring (N/A)
Building- Industrial- Tasnee Expansion, Foundation Coating 1600 Litre(s) Jubail Samsung, (JOMAC) Flour Daniel Aug-06
Factory (Tasnee)
Building- Industrial- Qurayyah Combined Cycle Coating, Surface 43 drums Dammam Arabian Bemco, Saudi Electric Company Feb-07
Factory Power Plant, (Saudi Treatment, Waterproofing (Unicorp
Electric Company) contarcting)
Building- Industrial- JESCO, (SABIC) Grouting and 10 drums Jubail Azmeel Royal Commission Feb-07
Factory Waterproofing
Building- Industrial- Qurayyah Combined Cycle Grouts, Sealants, 25 Packs Dammam Arabian Bemco, Saudi Electric Company Mar-07
Factory Power Plant, (Saudi waterproofing and repair (Unicorp)
Electric Company)
Building- Industrial- Qurayyah Combined Cycle Grouting and adheisives 47 drum Qurrayah ARABIAN BEMCO, Saudi Aramco Feb-07
Power Station Power Plant, (Saudi (UNICORP)
Electric Company)
Building- Industrial- Qurayyah Combined Cycle sealent/adhesive/repair/w 20 Litre(s) Dammam Arabian Bemco, SEC May-07
Power Station Power Plant, (SEC) ater proofing (unicorp contarcting)
26/01/2011 Page 3 of 4
Transport- Railways- Haramain High Speed Rail Concrete Curing,Sub- 2000 Litre(s) Jeddah MASCO DAR Al Handasah Jun-10
Infrastructure Way, (Saudi Railways Structure Curing and
Organitation) dampproofing,Protective
Coating for Culverts
Transport- Railways- Haramain High Speed Rail Columns Repair,Concrete 4000 Litre(s) Jeddah MASCO DAR Al Handasah Jul-10
Infrastructure Way, (Saudi Railways Curing,Sub-Structure
Organitation) Curing and
dampproofing,Tie rods
filling
Transport- Railways- Haramain High Speed Rail Sub-Structure Curing and 400 Litre(s) Jeddah MASCO DAR Al Handasah Aug-10
Infrastructure Way, (Saudi Railways dampproofing,Expansion
Organitation) Joints Sealing,Bonding
Agent,Surface Repair
Transport- Roadways- Road Projects (Khamis Bating Plant 5000 Litre(s) Khamis Mushayt Mastoor Al-Saad Ministry of Transport Mar-06
Motorway Mushayt), (MOT) Company, (N/A)
26/01/2011 Page 4 of 4
CASE STUDY :
SARI-PRINCE SULTAN INTERSECTION
BRIDGE constructive solutions
o Products :
Nitomortar TS
Renderoc FC
Cebond
Nitoproof 10
Cebex 300
Conbextra HF
Project Background :
This project has been launched at 2009 by Jeddah Municipality as
a part of the municipality plan to resolve Jeddah traffic jam and
ease the traffic flow at the major intersections.
Hence, such a project required a high quality internationally
standardized materials which could fulfil the requirements and
meet their standards.
The Client, the Consultant and Main Contractor were looking for
a reliable company which could provide them with materials that
are durable, trusted and available with the essential technical and
site support at all times to solve any problem that might occur
during the project execution and give the accurate solutions and
suitable materials for the various cases.
Fosroc Solutions :
Fosroc has introduced the right solutions throughout the project
execution period taking into considerations each case separately
to specify the suitable material.
Nitomortar TS was used at Bridge Deck expansion joint system,
total quantity 1125 Kg.
Renderoc FC was used as a Fairing Coat, with a total quantity
11800 Kg.
Cebond was used as a Bonding Agent, total quantity 625 Ltrs.
Nitoproof 10 was used at Foundation Damproofing, total
Quantity 3600 Ltrs.
Cebex 300 was used for Post Tension Cables Grouting, total
quantity 150 Kg.
Conbextra HF was used for Bridge Deck Levelling , total quantity
1000Kg.
Page 1
SARI-PRINCE SULTAN
INTERSECTION BRIDGE
Renderoc FC & Cebond used for Concrete Surfaces Smoothing Expansion Joint System Installation
Fosam Company
Limited Telephone: Fax: Email:
Head Office: Industrial Area, Phase 4, +966 (2) 637 5345 +966 (2) 637 5891 fosam@fosroc.com
Road No. 414, Street No. 407. Jeddah
Saudi Arabia Certificate number 183099
www.fosroc.com Page 2