Material Safety Data Sheet: U.S. Department of Labor

Confidential
7/24/2003
Page 1
Material Safety Data Sheet
U.S. Department of Labor
May be used to comply with

OSHA's Hazard Communication Standard
29 CFR 1910.1200. Standard must be
consulted for specific requirements.
Occupational Safety and Health Administration

(Non-Mandatory Form)
Form Approved
OMB No. 1218-0072
Forms Published by WindowChem (707)864-0846
IDENTITY
Note: Blank spaces are not permitted. If any item is not applicable, or no
information is available, the space must be marked to indicate that.
INDICATOR EBT
Section I
Manufacturer's Name
Emergency Telephone Number
Address (Number, Street, City, State, and ZIP Code
Telephone Number for Information
KOCOUR CO
1-800-424-9300
4800 S. ST. LOUIS AVE.
1-773-847-1111
Date Prepared
CHICAGO,IL 60632
01/26/2007
2/5/2003
Signature of Preparer (optional
Section II - Hazardous Ingredients/Identity Information

Hazardous Components (Specific Chemical Identity; Common Name(s))
OSHA PEL
Other Limits
Recommended
ACGIH TLV
METHYL ALCOHOL-
200ppm(262 mg/m3) OSHA TWA
CAS# 67-56-1
250ppm(328 mg/m3)OSHA STEL
% (optional)
80-100%
200ppm(262 mg/m3)NIOSH TWA

250ppm(262mg/m3)NIOSH STEL
(METHYL ALCOHOL IS SUBJECT TO SARA SECTION 313 ANNUAL RELEASE REPORTING.
CERCLA SECTION 103 REPORTABLE QUANTITY- 5000 POUNDS).
ERIOCHROME BLACK T-
< 2.00%
CAS# 1787-61-7
THE pH IS APPROXIMATELY 6.0.
Section III - Physical/Chemical Characteristics
Boiling Point
Specific Gravity (H2O = 1)
149 DEG.F
Vapor Pressure (mm Hg)
< 1.00
Melting Point
97.25mmHg
Vapor Density (AIR = 1)
1.11
N/A
Evaporation rate
(Butyl Acetate = 1)
4.6
Solubility in Water
COMPLETELY SOLUBLE IN WATER.

Appearance and Odo
DARK PURPLE COLORED SOLUTION WITH AN ALCOHOL ODOR.

Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used
AS METHYL ALCOHOL
Flammable Limits
52 DEG. F , CLOSED CUP
LEL
14
UEL
36
Extinguishing Media
CARBON DIOXIDE, DRY CHEMICAL OR FOAM.

Special Firefighting Procedures
WEAR PROPER PERSONAL PROTECTION AND SELF CONTAINED BREATHING APPARATUS.

Unusual Fire and Explosion Hazards
FIRE OR EXPLOSION HAZARD WHEN EXPOSED TO HEAT, SPARKS,

OPEN FLAME OR OXIDIZING AGENTS.
EBT.XLS
Page 1
Confidential
7/24/2003
Page 2
Section V - Reactivity Data

Stability
Unstable
Stable
Conditions to Avoid
NO APPLICABLE INFORMATION FOUND.
XX
Incompatibility (Materials to Avoid)
OXIDIZING AGENTS.
Hazardous Decomposition or Byproducts
MAY RELEASE TOXIC FUMES UNDER FIRE CONDITIONS.
Hazardous
May Occur
Polymerization
Will Not Occur
Conditions to Avoid
Route(s) of Entry:
Inhalation?
XX
Section VI - Health Hazard Data
Health Hazards (Acute and Chronic
Skin?
YES
YES
Ingestion?
YES
CAN CAUSE SKINN IRRITATION ON CONTACT. PROLONGED CONTACT CAN CAUSE DERMITITIS
PROLONGED INHALATION CAN CAUSE NAUSEA AND/OR DIZZINESS.
INGESTION CAN CAUSE BLINDNESS OR POSSIBLY BE FATAL.
Carcinogenicity
NTP?
IARC Monographs?
NON CARCINOGENIC
OSHA Regulated?
Signs and Symptoms of Exposure
RED OR INFLAMED SKIN, NAUSEA OR DIZZINESS.
Medical Conditions
Generally Aggravated by Exposur
OPEN CUTS OR SKIN ABRASIONS. EXCESSIVE INHALATION
CAN IRRITATE THE UPPER RESPIRATORY TRACT.
Emergency and First Aid Procedure
(INHALATION) REMOVE TO FRESH AIR (SKIN & EYES) FLUSH WITH WATER 15 MINS;INCLUDING UNDER
EYELIDS (INGESTION) INDUCE VOMITING & SEEK IMMEDIATE MEDICAL ATTENTION.

Section VII - Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spille
CONTAIN SPILL AND ABSORB WITH AN INERT MATERIAL (ie; SAND) .

HOLD FOR PROPER DISPOSAL.
Waste Disposal Method
ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.
Precautions to be Taken in Handling and Storag
DO NOT STORE IN DIRECT SUNLIGHT. KEEP AWAY FROM HEAT SOURCES AND SOURCES OF IGNITION
STORE AWAY FROM OXIDIZING AGENTS.
Other Precautions
KEEP AT ROOM TEMPERATURE WITH CAP TIGHTLY CLOSED.
Section VIII - Control Measures
Respiratory Protection (Specify Type
NIOSH APPROVED RESPIRATOR ADEQUATE TO REDUCE EXPOSURE TO BELOW LIMITS
Ventilation
Local Exhaust
Special
Mechanical (General
Other
LISTED IN SECTION II.
NO APPLICABLE INFORMATION FOUND
FUME HOOD
Protective Gloves
EYE PROTECTION
ADEQUATE TO PROTECT THE SKIN.
Other Protective Clothing or Equipmen
SAFETY GOGGLES
LAB COAT OR APRON TO PROTECT THE CLOTHING.
Work/Hygenic Practices
WASH WITH SOAP AND WATER AFTER USE. FOLLOW ESTABLISHED SAFETY POLICIES.
EBT.XLS
Page 2

Material Safety Data Sheet: U.S. Department of Labor

Uploaded by

Copyright:

Available Formats

Material Safety Data Sheet: U.S. Department of Labor

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Material Safety Data Sheet: U.S. Department of Labor

Uploaded by

Copyright:

Available Formats

Confidential

Material Safety Data Sheet

U.S. Department of Labor

May be used to comply with

Occupational Safety and Health Administration

Emergency Telephone Number

Address (Number, Street, City, State, and ZIP Code

Telephone Number for Information

4800 S. ST. LOUIS AVE.

Section II - Hazardous Ingredients/Identity Information

200ppm(262 mg/m3) OSHA TWA

250ppm(328 mg/m3)OSHA STEL

200ppm(262 mg/m3)NIOSH TWA

Specific Gravity (H2O = 1)

COMPLETELY SOLUBLE IN WATER.

DARK PURPLE COLORED SOLUTION WITH AN ALCOHOL ODOR.

52 DEG. F , CLOSED CUP

CARBON DIOXIDE, DRY CHEMICAL OR FOAM.

WEAR PROPER PERSONAL PROTECTION AND SELF CONTAINED BREATHING APPARATUS.

FIRE OR EXPLOSION HAZARD WHEN EXPOSED TO HEAT, SPARKS,

Section V - Reactivity Data

NO APPLICABLE INFORMATION FOUND.

Incompatibility (Materials to Avoid)

Hazardous Decomposition or Byproducts

MAY RELEASE TOXIC FUMES UNDER FIRE CONDITIONS.

NO APPLICABLE INFORMATION FOUND.

Health Hazards (Acute and Chronic

Signs and Symptoms of Exposure

RED OR INFLAMED SKIN, NAUSEA OR DIZZINESS.

OPEN CUTS OR SKIN ABRASIONS. EXCESSIVE INHALATION

CAN IRRITATE THE UPPER RESPIRATORY TRACT.

Emergency and First Aid Procedure

EYELIDS (INGESTION) INDUCE VOMITING & SEEK IMMEDIATE MEDICAL ATTENTION.

Steps to be Taken in Case Material is Released or Spille

CONTAIN SPILL AND ABSORB WITH AN INERT MATERIAL (ie; SAND) .

Waste Disposal Method

ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.

Precautions to be Taken in Handling and Storag

KEEP AT ROOM TEMPERATURE WITH CAP TIGHTLY CLOSED.

Section VIII - Control Measures

Respiratory Protection (Specify Type

NIOSH APPROVED RESPIRATOR ADEQUATE TO REDUCE EXPOSURE TO BELOW LIMITS

LISTED IN SECTION II.

NO APPLICABLE INFORMATION FOUND

NO APPLICABLE INFORMATION FOUND.

ADEQUATE TO PROTECT THE SKIN.

Other Protective Clothing or Equipmen

LAB COAT OR APRON TO PROTECT THE CLOTHING.

You might also like