7.

1 Sound System
Drawing of Component
Drawing of CD Player˖

1-Two-Strand CD Player

Tweeter Woofer

Tweeter Woofer
Instruction of Main Engine Terminal

16 Explanatory Table of Terminal

372
1 / 9 ILL( Illumination )(+)
Left Rear 10 Right Rear Loudspeaker(-)
2
Loudspeaker(+)
Left Front 11 Right Front Loudspeaker(-)
3
Loudspeaker(+)
Right Front 12 /
4
Loudspeaker(+)
Right Rear 13 /
5
Loudspeaker(+)
6 ILL(Illumination)(-) 14 Left Front Loudspeaker(-)
7 ACC 15 Left Rear Loudspeaker(-)
8 Memory Power Supply 16 Grounding
Replacement of Sound System
1 CD Player
1) Removal Step˖
ķ Use slotted screwdriver to pry off center control panel.
Ĺ Unscrew four bolts from radio.
ĺ Pull out CD player forward, disconnect electrical connector, remove sound host assembly.

For specific removal of center control panel, please refer Use straight screwdriver to remove four bolts from here
to Interior and Exterior
3) Install in the reverse order of removal, check radio and rape player for normal working condition.

2 Antenna Replacement
ķ Disconnect the connector between antenna and
transition wire in the trim panel located in downside
of column A.

373
 ĸ Pull out pillar aerial from outside of column A.

2) Installation Step˖
Install in the reverse order of removal.
Replacement of Woofer
1 Removal Step˖
1) Remove inside door trim panel.
2) Disconnect electrical connector on woofer.
3) Remove bolts of woofer.
4) Remove woofer.

2.Installation Step˖
Install in the reverse order of removal.

Replacement of Tweeter
1 Removal Step
1) Use slotted screwdriver to insert into tweeter frame,
pry off tweeter.
Caution
■Do not touch the glass on the frame to avoid glass
damage.
2) Disconnect the connector behind tweeter.
Remove tweeter.

2 Installation Step
Install in the reverse order of removal.
Malfunction Diagnosis
The acoustics of this vehicle model is CD player with USB_MP3 functions. Loudspeaker with left channel was installed
inside left door; loudspeaker with right channel was installed inside right door.
As you feel that some functions of auto sound failed, before drving to workshop, please read operation instructions in the
manual carefully,

Conduct inpection by way of looking at the following table, which will be helpful for you to troubleshoot malfunction. If
the malfunction can not be troubleshot, please drive the vehicle to after-sales service workshop. Do not remove and
repair the vehicle by yourself.
374
Slight incorrect operation may be mistaken for malfunction, therefore, please confirm it according to following table.
Malfunction Diagnosis List of Sound System
Symptom Causes Countermeasures
Replace a new protective tube with same
1.Power supply fuse burnout
specification
Plug output plug of power supply into
2.Looseness or poor contact of output plug of
Can not turn on output socket of host power supply again
power supply and host socket
or replace output plug
Use some object with sharp end to touch
3.Machine has been locked up
reset key on the panel
No image 1.Brightness adjustment of LCD is too faint Please adjust brightness of LCD
Interference happened Discontinue reception/MP3 playing
Drive on uneven road
as playing sound temporarily
Intermittent sound at Check connection condition of electrical
Incorrect power supply connection
times wire
1.Turn volume control button to minimum
Adjust volume to moderate level
No sound in the position
loudspeaker Check electrical wire and connection
2.Incorrect connection
condition
AS automatic
pre-position can not Weak signal Store radio stations by hand
work normally
Noise generated as
Antenna has not been connected and fixed Connect and fasten antenna
listening to the radio
Ensure that there is no short circuit
1.Check whether there is short circuit between
Can not get much between output cable of loudspeaker and
output cable of loudspeaker and ground
volume ground
2.Check host for high temperature Check temperature condition of host
1.Check whether song format in the U flash disk This machine only support MP3ǃWMA
is correct or not and other common format
USB can not be read
2.Check interface of U flash disk for good
Ensure good connection of U flash disk
connection
Displayer displays Check disc for correct placement.
Displayer displays “ERROR”
“ERROR” Check disc for damage or dirtiness.
As weather is cold, humidity may be
condensated on laser head. Turn host to
CD failed to play CD failed to play
reception position for 5 minutes and make
humidity evaporate.
Displayer displays “NO Check whether CD disc ha been inserted into
Displayer displays“NO CD”
CD” CD player.
WW Scrubbing System of Windscreen Wiper
Front Windscreen Wiper
Installation Position

375