19012.10 SDSR Stat X Class 1.4S
19012.10 SDSR Stat X Class 1.4S
19012.10 SDSR Stat X Class 1.4S
2.1 Classification
OSHA Regulatory Status
All 3 chemicals listed below are not stored as raw loose powder but homogenously blended and pressed into a single solid
aerosol forming compound pellet. Exposure to raw dust from the pellet is very limited which may contain any of the 3
chemicals listed in Section 3.
Potassium nitrate: Oxidizer solid
Dicyandiamide: Not a hazardous substance or mixture
Phonolic resin: This chemical is considered hazardous under 29 CFR 1910.1200 (Hazard Communication)
Hazard Statements
Potassium nitrate dust:
May intensity fire; oxidizer (H272)
Dicyandiamide dust: Not a hazardous substance or mixture
Page 1 of 5
Safety Data Sheet according to Regulation (EC) No. 1907/2006 & Amendment 987/2008 (REACH ) & HazCom 2012
Phenolic Resin dust:
Causes skin irritation (H315)
Causes eye irritation (H319)
May cause respiratory irritation (H335)
Precautionary Statements
Potassium nitrate: Keep/store away from clothing/combustible materials
Prevention
Wash face, hands and any exposed skin thoroughly after handling. Wear protective gloves/protective clothing/eye
protection/face protection. Avoid breathing particles/dust/gas. Handle in accordance with good industrial hygiene and safety
practice. Keep away from heat.
Response
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue
rising. If eye irritation persists: Get medical advice/attention.
IF ON SKIN: Wash with plenty of soap and water. If skin irritation or rash occurs: Get medical advice/attention.
IF ON CLOTHING: Dispose of contaminated clothing and gloves after use in accordance with applicable laws and good
industrial hygiene practices. Contaminated clothing should not be allowed out of the workplace unless well rinsed with water.
Disposal
Dispose of contents/container to an approved waste disposal plant.
Hazardous components: Does not contain dangerous materials as defined by ordinance on hazardous materials.
Components –
CAS# Weight COMMENTS:
Chemical (Hazardous
%
Components ≥ 1%)
Potassium Nitrate 7757-79-1 75.0 Components are blended and pressed into a highly stable, molded
ECHA Registration no. form. Molded composition is contained within a sealed double-
01-2119488224-35-0066 walled stainless steel housing – no environmental exposure. Upon
generator unit activation these chemical elements are not
DCDA 461-58-5 16.5 discharged from the unit but are fully consumed by an internal
chemical reaction.
d
Organic Resin 9003-35-4 8.5
Appearance & Odor: Beige to white in color. No odor.
Auto-Ignition Temperature: 3000 C
Solubility in Water: Slightly Soluble
Page 2 of 5
Safety Data Sheet according to Regulation (EC) No. 1907/2006 & Amendment 987/2008 (REACH ) & HazCom 2012
SECTION 5: Firefighting Measures
In the event of a fire, evacuate the area and inform emergency services. Ignition of Stat-X produces a fire-suppression
aerosol. Water may be used as an additional suppression agent.
If these devices are spilled they can be safely recovered by hand and should be inspected for damage prior to repacking.
Suspect or damaged articles should be labeled and consigned for correct destruction.
Store in temperate conditions. Avoid shock, electric currents, static discharge, excessive heat and extended
periods of storage at temperatures greater than 65°C.
Respiratory Protection Ventilate area completely after discharge. Do not enter area prior to complete venting
of enclosure. Use filter mask as necessary during clean-up.
Hand Protection Wear gloves if handling generators prior to cooling.
Eye Protection Safety glasses are advisable.
Skin Protection N/A
These devices are extremely stable below 125°C. They are packaged to protect the articles from electrical power and shock. As
with any stored products, stored packaging should be protected from fire and high temperatures.
Toxic by-products of combustion are extremely low. Main by-products are listed below with 15-minute TWA values for a
3
maximum 100g/m concentration in a hermetically sealed volume.
NO 0.97
CO 84.20
These devices are sealed and present no ecological hazards. The aerosol produced upon ignition has very low global
warming potential and an ozone depletion potential = 0.
Page 3 of 5
Safety Data Sheet according to Regulation (EC) No. 1907/2006 & Amendment 987/2008 (REACH ) & HazCom 2012
SECTION 14: Transport Information
Safety, health and environmental regulations/legislation specific for the substance or mixture
EU regulations
Phenolic Resin:
Regulation (EC) No. 1005/2009 on substances that deplete the ozone layer, Annex I, as amended:
Not listed.
Regulation (EC) No. 1005/2009 on substances that deplete the ozone layer, Annex II, as amended:
Not listed.
Regulation (EC) No. 850/2004 On persistent organic pollutants, Annex I as amended:
Not listed.
Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 1 as
amended:
Not listed.
Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 2 as
amended:
Not listed.
Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 3 as
Amended:
Not listed.
Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex V as
amended
Not listed.
Regulation (EC) No. 166/2006 Annex II Pollutant Release and Transfer Registry, as amended
Not listed.
Regulation (EC) No. 1907/2006, REACH Article 59(1) Candidate List as currently published by ECHA
Not listed.
Authorizations
Page 4 of 5
Safety Data Sheet according to Regulation (EC) No. 1907/2006 & Amendment 987/2008 (REACH ) & HazCom 2012
Restrictions on use
Regulation (EC) No. 1907/2006, REACH Annex XVII Substances subject to restriction on marketing and use
as amended
FORMALDEHYDE (CAS 50-00-0)
Directive 2004/37/EC: on the protection of workers from the risks related to exposure to carcinogens and
mutagens at work, as amended:
FORMALDEHYDE (CAS 50-00-0)
Directive 92/85/EEC: on the safety and health of pregnant workers and workers who have recently given
birth or are breastfeeding, as amended:
FORMALDEHYDE (CAS 50-00-0)
Other EU regulations
Other regulations
The product is classified and labelled in accordance with EC directives or respective national laws.
National regulations
This preparation is not classified as dangerous according to European Union legislation. Young people under
18 years old are not allowed to work with this product according to EU Directive 94/33/EC on the protection
of young people at work. Follow national regulation for work with chemical agents.
U.S. INFORMATION
Potassium Nitrate:
TSCA 8(b) inventory: Potassium Nitrate
CALIFORNIA PROPOSITION 65: Potassium Nitrate (CAS 7757-79-1) is not listed.
Clean Water Act (CWA): No product found
Phenolic Resin:
CALIFORNIA PROPOSITION 65: Formaldehyde (CAS 50-00-0) is listed.
Clean Water Act (CWA): Hazardous substance
Disclaimer: The information contained herein is accurate to the best knowledge and belief of Fireaway Inc.,
and is intended to describe the product for health, safety, and environmental requirements only. It is not
intended and should not be construed as a warranty. Consult Fireaway for further information.
Page 5 of 5
Safety Data Sheet according to Regulation (EC) No. 1907/2006 & Amendment 987/2008 (REACH ) & HazCom 2012