Claims (2)
1. Способ управления подачей топлива, заключающийся в том, что подают топливо сначала через один уровень отверстий, а затем и позже во время цикла подачи топлива через два уровня отверстий одновременно, отличающийся тем, что осуществляют, как минимум, один предварительный до основного и, как минимум, один впрыск после основного, при этом на каждом предварительном впрыске перемещают иглу вверх механическим путем в течение времени переключения заданного при впрыске с помощью кулачков с микропрофилями с малой высотой, на каждом впрыске после основного, перемещают иглу вверх механическим путем в течение времени переключения заданного при впрыске с помощью кулачков с микропрофилями с высотой равной высоте микропрофилей для предварительного впрыска, взаимодействующих с пластиной кинематически соединенной с иглой форсунки, одновременно с иглой форсунки перемещают шток первого механического клапана вверх, открывают канал для подвода топлива под иглу форсунки пропорционально подъему штока первого механического клапана, подают топливо под иглу форсунки и в отверстия распылителя, одновременно с иглой форсунки перемещают шток второго механического клапана вверх, открывают канал для отвода топлива от камеры управления над иглой, отводят топливо из камеры над иглой в гидроаккумулятор низкого давления, удерживают иглу форсунки, штоки первого и второго механических клапанов в верхнем положении на время длительности каждого предварительного впрыска и каждого впрыска после основного впрыска механическим путем при взаимодействии микропрофилей с заданной малой высотой, равной для предварительного впрыска и для впрыска после основного, с выпуклой поверхностью постоянного радиуса на конце пластины, после окончания каждого предварительного впрыска и каждого впрыска после основного иглу форсунки перемещают в нижнее крайнее положение, одновременно штоки первого и второго механических клапанов перемещают вниз закрывают канал для подвода топлива под иглу и перекрывают канал для отвода топлива от камеры управления над иглой в гидроаккумулятор низкого давления, подают топливо под высоким давлением в камеру управления над иглой при перемещении иглы вниз, удерживают в течение времени заданного при каждой отсечке между двумя последовательными впрысками иглу форсунки и штоки первого и второго механических клапанов в крайнем нижнем положении, осуществляют, как минимум, один основной впрыск одновременно через отверстия первого и второго уровней с длительностью основного впрыска, для этого перемещают иглу в верхнее положение механическим путем в течение времени переключения заданного при впрыске с помощью кулачков с микропрофилями с большей высотой, взаимодействующих с пластиной, одновременно с иглой форсунки перемещают шток первого механического клапана вверх на постоянную высоту, пропорциональную высоте микропрофиля для реализации основного впрыска, открывают канал для подвода топлива под иглу и втулку форсунки пропорционально подъему штока первого механического клапана, одновременно с иглой форсунки перемещают шток второго механического клапана вверх, открывают канал для отвода топлива от камеры управления над иглой и втулкой, отводят топливо из камеры управления над иглой и втулкой в гидроаккумулятор низкого давления, подают топливо под давлением сначала под иглу через отверстия первого уровня, после перемещения иглы на некоторую промежуточную высоту, затем перемещают одновременно иглу и втулку и штоки первого и второго механических клапанов в верхнее положение и подают топливо под давлением под втулку в отверстия второго уровня, осуществляют основной впрыск через отверстия второго уровня большего диаметра одновременно с впрыском через отверстия первого уровня, удерживают иглу и втулку в верхнем положении на время длительности основного впрыска механическим путем при взаимодействии микропрофиля с большей высотой с выпуклой поверхностью постоянного радиуса на конце пластины или дополнительно перемещают иглу и втулку и штоки первого и второго механических клапанов по заданному закону на время длительности основного впрыска при взаимодействии микропрофилей с заданной переменной высотой по длине микропрофиля с выпуклой поверхностью постоянного радиуса, после окончания каждого основного впрыска с заданной постоянной или переменной высотой микропрофиля для реализации основного впрыска иглу и втулку форсунки перемещают в нижнее крайнее положение с помощью пружин, одновременно с иглой штоки первого и второго механических клапанов перемещают вниз, перекрывают канал для подвода топлива высокого давления под иглу и втулку, перекрывают канал для отвода топлива от камеры управления над иглой и втулкой в гидроаккумулятор низкого давления, подают топливо под высоким давлением в камеру управления над иглой и втулкой при перемещении иглы и втулки вниз, удерживают в течение времени заданного при каждой отсечке между двумя последовательными впрысками иглу и втулку форсунки, а также штоки первого и второго механических клапанов в положении при отсечке или осуществляют впрыск после основного одновременно через отверстия первого и второго уровней с высотой микропрофилей взаимодействующих с платиной с выпуклым концом, соединенной с иглой кинематически, равной или большей высоты микропрофилей для реализации основного впрыска, перемещают пластину вдоль оси вала кулачка с микропрофилями с набегающей кромкой микропрофиля, параллельной оси кулачка и сбегающей кромкой микропрофиля, параллельной скосу выпуклой поверхности на конце пластины, изменяют длину выпуклой поверхности вдоль скоса при непрерывном управлении и изменяют длительность каждого впрыска непрерывно или перемещают пластину вдоль оси вала кулачка с микропрофилями с набегающей кромкой микропрофиля на кулачке, параллельной оси вала кулачка и сбегающей кромкой микропрофиля, параллельной оси вала кулачка, изменяют длину выпуклой поверхности вдоль оси вала ступенчато и изменяют длительность впрыска ступенчато.1. The method of controlling the fuel supply, which consists in the fact that the fuel is supplied first through one level of holes, and then later during the fuel supply cycle through two levels of holes at the same time, characterized in that at least one preliminary to the main and, at least one injection after the main injection, with each preliminary injection moving the needle up mechanically during the switching time specified during the injection using cams with microprofiles with a low height, at each injection after the main one, move the needle up mechanically during the switching time set during injection using cams with microprofiles with a height equal to the height of microprofiles for preliminary injection, interacting with the plate kinematically connected to the nozzle needle, simultaneously move the first mechanical valve rod upward with the nozzle needle, open the channel to supply fuel under the nozzle needle in proportion to the rise of the rod of the first mechanical valve, fuel is supplied under the nozzle needle and into the spray holes while eating, at the same time as the nozzle, the nozzles move the rod of the second mechanical valve up, open the channel for removing fuel from the control chamber above the needle, divert fuel from the chamber above the needle into the low pressure accumulator, hold the nozzle needle, the rods of the first and second mechanical valves in the upper position for a while the duration of each pre-injection and each injection after the main injection by mechanical means during the interaction of microprofiles with a given low height equal to the preliminary injection and the injection after the main one, with a convex surface of constant radius at the end of the plate, after the end of each preliminary injection and each injection after the main needle, the nozzles are moved to the lower extreme position, while the rods of the first and second mechanical valves move down, close the channel for supplying fuel under the needle and block the channel to divert fuel from the control chamber above the needle into the low pressure accumulator, high-pressure fuel is supplied to the control chamber above the needle when moving the needle down, hold for the time specified at each cut-off between two successive injections, the nozzle needle and the rods of the first and second mechanical valves in the lowest position, carry out at least one main injection simultaneously through the holes of the first and second levels with the duration of the main injection, for this move the needle to the upper position mechanically during the switching time specified during injection using cams with microprofiles with a higher height interacting with the plate, one at the same time, with the needle, the nozzles move the stem of the first mechanical valve up to a constant height proportional to the height of the microprofile for realizing the main injection, open the channel for supplying fuel under the needle and the nozzle sleeve in proportion to the rise of the rod of the first mechanical valve, simultaneously with the nozzle needle move the rod of the second mechanical valve up, open the channel for the removal of fuel from the control chamber above the needle and the sleeve, divert the fuel from the control chamber above the needle and the sleeve into the accumulator low pressure, first supply fuel under pressure, first under the needle through the holes of the first level, after moving the needle to a certain intermediate height, then move the needle and sleeve and the rods of the first and second mechanical valves to the upper position and supply fuel under pressure to the sleeve in the holes of the second level carry out the main injection through the holes of the second level of a larger diameter simultaneously with the injection through the holes of the first level, hold the needle and the sleeve in the upper position for the duration of the main mechanical injection during the interaction of a microprofile with a higher height with a convex surface of constant radius at the end of the plate or additionally move the needle and sleeve and the stems of the first and second mechanical valves according to a given law for the duration of the main injection during the interaction of microprofiles with a given variable height along the length of the microprofile with a convex surface of constant radius, after the end of each main injection with a given constant or variable height of the microprofile for realizing During the main injection, the nozzle and the nozzle bushing are moved to the lower extreme position using springs, simultaneously with the needle, the rods of the first and second mechanical valves are moved down, block the channel for supplying high pressure fuel under the needle and bushing, and block the channel for removing fuel from the control chamber above the needle and the sleeve into the low-pressure accumulator, fuel is fed under high pressure to the control chamber above the needle and the sleeve while moving the needle and sleeve down, hold for the time specified at each the hole between two consecutive injections, the needle and the nozzle bushing, as well as the stems of the first and second mechanical valves in the cut-off position, or inject after the main one simultaneously through the openings of the first and second levels with the height of microprofiles interacting with a platinum with a convex end connected kinematically equal to the needle, equal to or greater height of the microprofiles for the implementation of the main injection, move the plate along the axis of the cam shaft with microprofiles with a rolling edge of the microprofile parallel to the axis k the lance and the creeping edge of the microprofile parallel to the bevel of the convex surface at the end of the plate, change the length of the convex surface along the bevel with continuous control and change the duration of each injection continuously or move the plate along the axis of the cam shaft with microprofiles with the running edge of the microprofile on the cam parallel to the axis of the cam shaft and the running edge of the microprofile parallel to the axis of the cam shaft changes the length of the convex surface along the axis of the shaft stepwise and changes the duration of the injection stepwise.
2.Устройство для управления подачей топлива, включающее форсунку с подпружиненной иглой с механическим приводом, мультипликатор перемещения, механический регулятор длительности впрыска, распылитель с одним уровнем отверстий, топливный насос высокого давления, гидравлический аккумулятор высокого давления, соединенный гидравлически с надыгольной и подыгольной камерами форсунки, отличающееся тем, что форсунка выполнена с иглой и соосной ей втулкой с двумя уровнями отверстий, устройство снабжено, гидравлическим аккумулятором низкого давления, двумя механическими клапанами со штоками, быстродействующим реверсивным механическим приводом, первый шток первого механического клапана соединен механически с иглой форсунки и перекрывает канал подвода топлива от гидроаккумулятора высокого давления под иглу и втулку, второй шток второго механического клапана соединен механически с иглой форсунки и перекрывает канал, соединяющий камеру над иглой и втулкой с гидроаккумулятором низкого давления, выход которого соединен со входом топливного насоса ывсокого давления, гидроаккумулятор высокого давления соединен каналом с камерой над иглой и втулкой, одновременно соединен через канал с первым механическим клапаном через кольцевые проточки в корпусе с нижней частью иглы и втулки, подыгольной камерой и камерой втулки, игла форсунки соединена механически с быстродействующим реверсивным механическим приводом для ее линейного перемещения, который снабжен, как минимум, одной пластиной для одного цилиндра с выпуклой поверхностью постоянного радиуса на одном конце пластины определенной длины выпуклой части, валом, соединенным кинематически с коленчатым валом с, как минимум, одним программным профилированным кулачком с, как минимум, одним микропрофилем на нем с постоянной заданной малой высотой, равной для предварительного впрыска и для впрыска после основного, для реализации, как минимум, одного предварительного впрыска и одного впрыска после основного через один уровень отверстий или с микропрофилем на нем с высотой для реализации впрыска после основного большей, чем высота профиля для предварительного впрыска при реализации впрыска после основного через два уровня отверстий с, как минимум, одним микропрофилем на нем с постоянной заданной большей высотой для реализации, как минимум, одного основного впрыска через два уровня отверстий или, как минимум, одним микропрофилем переменной высоты, изменяющимся по заданному закону по длине микропрофиля для реализации, как минимум, одного основного впрыска, все микропрофили отделены друг от друга промежутками по окружности кулачкового вала для реализации пауз между впрысками или выполнены без промежутков между микропрофилями, программные профилированные кулачки с микропрофилями заданной длины постоянной или переменной высотой выполнены с возможностью последовательного взаимодействия сначала с прямой частью, как минимум, одной пластины при ее перемещении из одного крайнего положения в другое, а затем с выпуклой поверхностью пластины постоянного радиуса при впрысках заданной длительности, выпуклая поверхность, как минимум, одной пластины выполнена со скосом непрерывной по ширине пластины длиной выпуклой концевой части, микропрофили выполнены с прямыми набегающими краями и косыми сбегающими концами, параллельными скосу выпуклой концевой части или ступенчатой по ширине пластины длиной выпуклой концевой части, а микропрофили при этом выполнены с прямыми набегающими и сбегающими краями, параллельными оси вала при регулировании длительности впрыска, каждая пластина выполнена с возможностью перемещении вдоль оси штока и иглы форсунки и соединена при этом напрямую или через мультипликатор перемещения с подпружиненным штоком и через него с иглой форсунки, каждая пластина выполнены с возможностью перемещения в плоскости, перпендикулярной или расположенной под углом к оси иглы и штока при регулировании длительности впрыска и соединена для этого шлицевым соединением со штоком, относительно которого перемещается пластина.
2. A device for controlling the fuel supply, including a nozzle with a spring-loaded needle with a mechanical drive, a movement multiplier, a mechanical regulator of the duration of injection, a spray with a single level of openings, a high-pressure fuel pump, a high-pressure hydraulic accumulator connected hydraulically to the nozzle and needle chamber of the nozzle, characterized in that the nozzle is made with a needle and a sleeve coaxial with two levels of holes, the device is equipped with a low-pressure hydraulic accumulator phenomena, with two mechanical valves with rods, a fast reversing mechanical actuator, the first stem of the first mechanical valve is mechanically connected to the nozzle needle and blocks the fuel supply channel from the high-pressure accumulator under the needle and the sleeve, the second stem of the second mechanical valve is mechanically connected to the nozzle needle and closes the channel connecting the chamber above the needle and the sleeve with a low pressure accumulator, the output of which is connected to the inlet of the high pressure fuel pump, a high-pressure modulator is connected by a channel to the chamber above the needle and the sleeve, at the same time is connected through the channel to the first mechanical valve through annular grooves in the housing with the lower part of the needle and the sleeve, the needle chamber and the sleeve chamber, the nozzle needle is mechanically connected to a high-speed reversing mechanical drive for its linear displacement, which is provided with at least one plate for one cylinder with a convex surface of constant radius at one end of the plate of a certain length of the convex part, a shaft, kinematically connected to the crankshaft with at least one programmed profiled cam with at least one microprofile on it with a constant predetermined low height, equal for preliminary injection and for injection after the main one, for realizing at least one preliminary injection and one injection after the main through one level of holes or with a microprofile on it with a height for realizing the injection after the main is greater than the height of the profile for preliminary injection when realizing the injection after through two levels of holes with at least one microprofile on it with a constant predetermined greater height for realizing at least one main injection through two levels of holes or at least one microprofile of variable height, which varies according to a given law along the length of the microprofile for the implementation of at least one main injection, all microprofiles are separated from each other by gaps around the circumference of the cam shaft for the implementation of pauses between injections or performed without gaps between microprofiles, the program profiled cams with microprofiles of a given length of constant or variable height are made with the possibility of sequential interaction, first with the straight part of at least one plate when it moves from one extreme position to another, and then with the convex surface of the plate of constant radius for injections of a given duration, convex the surface of at least one plate is slanted with a continuous along the width of the plate length of the convex end part, the microprofiles are made with straight oncoming and edges and oblique run-down ends parallel to the bevel of the convex end part or a step along the width of the plate, the length of the convex end part, and microprofiles are made with straight run-in and run-off edges parallel to the axis of the shaft when adjusting the injection duration, each plate is movable along the axis the rod and the nozzle needle and is connected directly or through a movement multiplier with a spring-loaded rod and through it with the nozzle needle, each plate is made with the possibility of movements in a plane perpendicular or at an angle to the axis of the needle and the rod when adjusting the injection duration and is connected for this by a splined connection to the rod relative to which the plate moves.