Tag Archives: North American Aviation Inc.

10 January 1956

Aviation, , , , , , , , , , , , ,
Lieutenant Barty R. Brooks, USAFR, standing on the wing of a North American Aviation F-86F Sabre, Korea, 1954. (U.S. Air Force)

10 January 1956: First Lieutenant Barty Ray Brooks, United States Air Force Reserve, a pilot assigned to the 1708th Ferrying Wing, Detachment 12, at Kelly Air Force Base, Texas, along with two other pilots from the same unit, Captain Rusty Wilson and Lieutenant Crawford Shockley, picked up three brand new F-100C Super Sabre fighters at the North American Aviation Inc. assembly plant at Air Force Plant 42, Palmdale, California. It was to be a short flight, as these three jets were being taken to nearby George Air Force Base, Adelanto, California, only 42.5 miles (68.4 kilometers) to the east. Brooks was flying F-100C-20-NA, serial number 54-1907.

This North American Aviation F-100C-25-NA Super Sabre, serial number 54-2099, is similar to the fighter flown by Lieutenant Brooks, 10 January 1956. (U.S. Air Force)
This North American Aviation F-100C-25-NA Super Sabre, serial number 54-2099, is similar to the fighter flown by Lieutenant Brooks, 10 January 1956. (U.S. Air Force)
This photograph shows the lower section of the nose gear strut of an F-100 Super Sabre. The scissors ling is the hinged assembly. A red pin is visible at teh center hinge. Thi spin had been removed by ground handlers to tow the fighter, but had not been reinstalled before Lt. Brooks' flight.
This photograph shows the lower section of the nose gear strut of an F-100 Super Sabre. The scissors link is the hinged assembly. A red pin is visible at the center hinge. This pin had been removed by ground handlers to tow the fighter, but had not been secured with a safety pin when it was reinstalled before Lt. Brooks’ flight. (Michael Benolkin)

The brief flight was uneventful until the pilots lowered the landing gear to land at George AFB. One of the other pilots saw that the scissors link joining the upper and lower sections of the nose gear strut on Brooks’ Super Sabre was loose. Concerned that he would not be able to steer the fighter after touching down, Brooks diverted to Edward Air Force Base, 36 miles (57 kilometers) to the northwest, where a larger runway and more emergency equipment was available. Captain Wilson escorted Lieutenant Brooks to Edwards.

The F-100C Super Sabre had no flaps and required a high speed landing approach. Lieutenant Brooks had only 674 total flight hours as a pilot, and just 39 hours in the F-100.

During his final approach to the runway Brooks allowed the fighter to slow too much and the outer portion of the wings stalled and lost lift. This shifted the wings’ center of lift forward, which caused the airplane to pitch up, causing even more of the outer wing to stall.

Lieutenant Brooks fought to regain control of the airplane, but he was unable to. At 4:27 p.m., Pacific Standard Time, the F-100 crashed on the runway and exploded. Barty Ray Brooks was killed.

Edwards Air Force Base is the center of flight testing for the U.S. Air Force. In preparation for a test later that afternoon, the base film crews had their equipment set up along the runway and captured the last seconds of Brook’s flight on film. This is the most widely seen crash footage, and is still in use in pilot training. It is named “The Sabre Dance.”

Still image from cine film of Barty Brooks’ F-100C Super Sabre just before it crashed at Edwards Air Force Base, 10 January 1956. (U.S. Air Force)

Barty Ray Brooks was born in Martha Township,  Oklahoma, 2 December 1929. He was the third child of Benjamin Barto Brooks, a farmer, and Maye Henry Brooks. The family later moved to Lewisville, Texas. Brooks graduated from Lewisville High School in 1948, then studied agriculture at Texas A&M University, College Station, Texas.

Barty Ray Brooks, 1950. (Aggieland ’50)

While at Texas A&M, Brooks was a member of the Reserve Officers Training Corps (R.O.T.C.). On graduation, 30 May 1952, Brooks was commissioned as a second lieutenant, United States Air Force Reserve.

Lieutenant Brooks was trained as a pilot at Columbus Air Force Base, Mississippi, and Laredo Air Force Base, Texas. In 1954, he was assigned to the 311th Fighter Bomber Squadron, 58th Fighter Bomber Group, Taegu Air Base (K-2), Republic of South Korea. Brooks flew the Republic F-84 Thunderjet and North American Aviation F-86 Sabre. When he returned to the United States he was assigned to the 1708th Ferrying Wing.

The remains of 1st Lieutenant Barty Ray Brooks were interred at the Round Grove Cemetery, Lewisville, Texas.

The article, “The Deadly Sabre Dance,” by Alan Cockrell is highly recommended:

http://www.historynet.com/deadly-sabre-dance.htm

© 2018, Bryan R. Swopes

29 December 1949

Aviation, , , , , , , , , , , , , , ,
Jackie Cochran with her Cobalt Blue North American Aviation P-51C Mustang, N5528N, Thunderbird, circa December 1949. (FAI)

29 December 1949: Jackie Cochran (Lieutenant Colonel, United States Air Force Reserve) flew her North American Aviation P-51C Mustang, Thunderbird, CAA registration N5528N, to two Fédération Aéronautique Internationale (FAI) Class C-1 world speed records of 703.38 kilometers per hour (437.06 miles per hour)¹ and a U.S. National record of 703.275 kilometers per hour (436.995 miles per hour) over the 500 kilometer (310.7 mile) Desert Center–Mt. Wilson course in the Colorado Desert of southern California.

She would later be awarded the first of three Distinguished Flying Crosses for this series of flight records.

Left profile drawing of Thunderbird, Jackie Cochran’s unlimited class North American Aviation P-51C Mustang, N5528N. (Image courtesy of Tim Bradley, © 2014)
National Aeronautic Association Certificate of Record in the San Diego Air and Space Museum Archive. (Bryan R. Swopes)
National Aeronautic Association Certificate of Record in the San Diego Air and Space Museum Archive. (Bryan R. Swopes)
Jackie Cochran’s North American Aviation P-51C Mustang, N5528N. (FAI)

Thunderbird was Jackie Cochran’s third P-51 Mustang. She had purchased it from Academy Award-winning actor and World War II B-24 wing commander James M. Stewart just ten days earlier, 19 December 1949.

According to Civil Aviation Administration records, the airplane had been “assembled from components of other aircraft of the same type.” It has no U.S. Army Air Corps serial number or North American Aviation manufacturer’s serial number. The C.A.A. designated it as a P-51C and assigned 2925 as its serial number. It was certificated in the Experimental category and registered N5528N.

Thunderbird had won the 1949 Bendix Trophy Race with pilot Joe De Bona, after he had dropped out of the 1948 race. Its engine had been upgraded from a Packard V-1650-3 Merlin to a V-1650-7 for the 1949 race.

Cobalt Blue North American Aviation P-51C Mustang N5528N with Joe De Bona’s race number, 90. (Unattributed).

Jackie Cochran set three world speed records with Thunderbird. In 1953, she sold it back to Jimmy Stewart. After changing ownership twice more, the P-51 crashed near Scott’s Bluff, Nebraska, 22 June 1955 and was totally destroyed. Pilot James M. Cook parachuted with minor injuries.

The P-51B and P-51C Mustangs are virtually identical. The P-51Bs were built by North American Aviation, Inc., at Inglewood, California, while P-51Cs were built at North American’s Dallas, Texas, plant. They were 32 feet, 2.97 inches (9.829 meters) long, with a wingspan of 37 feet, 0.31-inch (11.282 meters) and overall height of 13 feet, 8 inches (4.167 meters) high. The fighter had an empty weight of 6,985 pounds (3,168 kilograms) and a maximum gross weight of 11,800 pounds (5,352 kilograms).

P-51Bs and Cs were powered by a liquid-cooled, supercharged, 1,649-cubic-inch-displacement (27.04-liter) Packard V-1650-3 or -7 Merlin single overhead cam (SOHC) 60° V-12 engine which produced 1,380 horsepower at Sea Level, turning 3,000 r.p.m and 60 inches of manifold pressure (V-1650-3) or 1,490 horsepower at Sea Level, turning at 3,000 r.p.m. with 61 inches of manifold pressure (V-1650-7). These were license-built versions of the Rolls-Royce Merlin 63 and 66. The engine drove a four-bladed Hamilton-Standard Hydromatic constant speed propeller with a diameter of 11 feet, 2 inches (3.404 meters).

The P-51B/C had a cruise speed of 362 miles per hour (583 kilometers per hour) and the maximum speed was 439 miles per hour (707 kilometers per hour) at 25,000 feet (7,620 meters). The service ceiling was 41,900 feet (12,771 meters). With internal fuel, the combat range was 755 miles (1,215 kilometers).

In military service, armament consisted of four Browning AN/M2 .50-caliber machine guns, mounted two in each wing, with 350 rounds per gun for the inboard guns and 280 rounds per gun for the outboard.

1,988 P-51B Mustangs were built at North American’s Inglewood, California plant and another 1,750 P-51Cs were produced at Dallas, Texas. This was nearly 23% of the total P-51 production.

According to the Smithsonian Institution National Air and Space Museum, “At the time of her death in 1980, Jacqueline Cochran held more speed, altitude, and distance records than any other male or female pilot in aviation history.”

Identical to the Inglewood, California-built North American Aviation P-51B Mustang, this is a Dallas, Texas-built P-51C-1-NT, 42-103023. (North American Aviation, Inc.)

¹ FAI Record File Numbers 4476 and 12323

© 2016, Bryan R. Swopes

29 December 1941

Aviation, , , , , , , , , , ,
North American Aviation XP-51 Mustang 41-038 at Langley Field, Virginia, 29 December 1941. (NASA)

29 December 1941: The first North American Aviation XP-51 fighter prototype, Air Corps serial number 41-038, arrived at the National Advisory Committee for Aeronautics Langley Memorial Aeronautical Laboratory, Langley Field, Hampton, Virginia, for flight testing. This airplane was the fourth production Royal Air Force Mustang Mk.I, North American serial number 73-3101.

The test program resulted in an improved aileron design which significantly improved the Mustang’s maneuverability. The new aileron was used on all production models.

North American Aviation XP-51 41-038 at the NACA Langley Memorial Aeronautical Laboratory. (NASA)

41-038 was returned to Wright Field on 2 November 1942. The second XP-51, 41-039, arrived at Langley in March 1943 for continued testing.

The Mustang Mk.I (NAA Model NA-73) was a single-place, single-engine fighter of all metal construction. It was 32 feet, 3 inches (9.830 meters) long with a wingspan of 37 feet, ½-inch (11.290 meters) and overall height of 12 feet, 2½ inches (3.719 meters). The airplane’s empty weight was 6,280 pounds (25,848.6 kilograms) and loaded weight was 8,400 pounds (3,810.2 kilograms).

North American Aviation XP-51 41-038 at NACA Langley Memorial Aeronautical Laboratory, right profile. (NASA)

The Mustang Mk.I/XP-51 was powered by a liquid-cooled, supercharged 1,710.60-cubic-inch-displacement (28.032 liter) Allison Engineering Company V-1710-F3R (V-1710-39) single overhead cam 60° V-12 engine, with a compression ratio of 6.65:1 and a single-stage, single-speed supercharger. This was a right-hand tractor engine (the V-1710 was built in both right-hand and left-hand configurations) which drove a 10 foot, 6 inch (3.200 meter) diameter, three-bladed, Curtiss Electric constant-speed propeller through a 2.00:1 gear reduction.

The V-1710-39 had a Normal Power rating of 880 horsepower at 2,600 r.p.m. at Sea Level; Take Off Power rating of 1,150 horsepower at 3,000 r.p.m. at Sea Level, with 44.5 inches of manifold pressure (1.51 Bar), 5 minute limit; and a War Emergency Power rating of 1,490 horsepower at 3,000 r.p.m., with 56 inches of manifold pressure (1.90 Bar). The V-1710-F3R was 3 feet, ¾ inches (0.934 meters) high, 2 feet, 5-9/32 inches (0.744 meters) wide and 7 feet, 1-5/8 inches (2.175 meters) long. It had a dry weight of 1,310 pounds (594 kilograms).

North American Aviation XP-51 41-038 at NACA Langley Memorial Aeronautical Laboratory. (NASA)

The XP-51 tested at Wright Field had a maximum speed of 382.0 miles per hour (614.8 kilometers per hour) at 13,000 feet (3,962 meters) at wide open throttle, and cruise speed of 300 miles per hour (483 kilometers per hour).

Below 20,000 feet (6,096 meters), the Mustang was the fastest fighter in the world. The Mk.I was 30 m.p.h. (48 kilometers per hour) faster than its contemporary, the Curtiss P-40 Warhawk, though both used exactly the same engine. Below 15,000 feet (4,572 meters), the Mustang was also 30–35 m.p.h (48–56 km/h) faster than a Supermarine Spitfire, which was equipped with the more powerful Roll-Royce Merlin V-12.

The service ceiling was 30,800 feet (9,388 meters) and range was 750 miles (1,207 kilometers).

North American Aviation XP-51 41-038 at NACA Langley Memorial Aeronautical Laboratory, rear view. (NASA)

Armament consisted of two synchronized Browning AN-M2 .50-caliber machine guns mounted in the nose under the engine and firing through the propeller, and two more .50-caliber and four Browning .303 Mk.II machine guns in the wings.

North American Aviation XP-51 instrument panel. (U.S. Air Force)

Two Mustang Mk.Is, AG348 and AG354, were taken from the first RAF production order and sent to Wright Field for testing by the U.S. Army Air Corps. These airplanes, assigned Air Corps serial numbers 41-038 and 41-039, were designated XP-51. They would be developed into the legendary P-51 Mustang. In production from 1941 to 1945, a total of 16,766 Mustangs of all variants were built.

North American XP-51 41-038 was transferred to the Smithsonian Institution National Air and Space Museum. It was restored in 1976. It is now in the collection of the EAA AirVenture Museum, Oshkosh, Wisconsin. It has a current FAA registration number, N51NA.

North American Aviation XP-51 41-038 in the collection of the Experimental Aircraft Association AirVenture Museum, Oshkosh, Wisconsin. (EAA AirVenture Museum)
North American Aviation XP-51 41-038 in the collection of the Experimental Aircraft Association AirVenture Museum, Oshkosh, Wisconsin. (EAA AirVenture Museum)

© 2018, Bryan R. Swopes

27 December 1951

Aviation, , , , , , , , , , ,
The first prototype North American Aviation XFJ-2B Fury, Bu. No. 133756, lifts off the runway at Los Angeles International Airport, 27 December 1951. (north American Aviation)
The first prototype North American Aviation XFJ-2B Fury, Bu. No. 133756, lifts off the runway at Los Angeles International Airport, 27 December 1951. (San Diego Air and Space Museum Archive)
North American Aviation XFJ-2B Fury prototype Bu. No. 133756 climbs out after takeoff from Los Angeles International Airport, 27 December 1951. (San Diego Air and Space Museum Archive)
North American Aviation XFJ-2B Fury prototype Bu. No. 133756 climbs out after takeoff from Los Angeles International Airport, 27 December 1951. (San Diego Air and Space Museum Archive)

27 December 1951: The North American Aviation XFJ-2B Fury, Bu. No. 133756, made its first flight at Los Angeles International Airport with test pilot Robert Anderson Hoover at the controls.

The XFJ-2B was a prototype aircraft carrier-based fighter for the United States Navy and Marine Corps. It was modified from a standard production U.S. Air Force F-86E-10-NA Sabre day fighter. The primary difference was the substitution of four 20 mm Colt Mark 12 autocannon for the six .50-caliber Browning M-3 machine guns of the F-86E. 150 rounds per gun were carried. The aircraft was flown to the Naval Ordnance Test Station, Armitage Field, China Lake, California, for armament testing.

The second and third prototypes were unarmed but fitted with an arrestor hook, catapult points, folding wings and a lengthened nose gear strut to increase the fighter’s static angle of attack for takeoff and landings. These two prototypes were used for aircraft carrier trials.

Production FJ-2 Fury fighters were built at North American’s Columbus, Ohio plant, along with F-86F Sabres for the Air Force.

Prototype North American Aviation XFJ-2B Fury, Bu. No. 133756, in flight, eastbound, just southwest of the Palos Verdes Peninsula. Santa Monica Bay and the Santa Monica Mountains are in the background. (North American Aviation, Inc./Boeing)
Prototype North American Aviation XFJ-2B Fury Bu. No. 133756 in flight, eastbound, just southwest of the Palos Verdes Peninsula. Santa Monica Bay and the Santa Monica Mountains are in the background. (North American Aviation, Inc./Boeing)
North American Aviation test pilot Robert A. ("Bob") Hoover with XFJ-2 Fury, Bu. No. 133754, the second prototype. (North American Aviation, Inc.)
North American Aviation test pilot Robert A. (“Bob”) Hoover with XFJ-2 Fury Bu. No. 133754, the second prototype. Note the extended landing gear strut. (North American Aviation, Inc.)

Robert A. Hoover was one of the world’s best known exhibition pilots. He was a fighter pilot in the U.S. Army Air Corps during World War II. While flying a British Supermarine Spitfire with the 52nd Fighter Group based at Sicily, he was shot down, captured, and held as a prisoner of war at Stalag Luft I in Germany.

After 16 months in captivity, Hoover escaped, stole a Luftwaffe Focke-Wulf Fw 190 and flew it to The Netherlands.

After the war, Bob Hoover trained as a test pilot at Wright Field, Ohio, and remained in the Air Force until 1948. He worked as a test pilot for the Allison Division of General Motors, and then went on to North American Aviation.

Bob Hoover was famous  for flying aerobatic demonstrations around the world in his yellow P-51D Mustang and a twin-engine Shrike Commander, both built by North American Aviation.

Robert Anderson Hoover died 25 October 2016 at the age of 94 years.

Robert Anderson Hoover, Test Pilot, with North American Aviation F-100D-30-NA Super Sabre 55-3702A. (The Washington Post)

© 2018, Bryan R. Swopes

22 December 1949

Aviation, , , , , , , , , ,
North American Aviation YF-86D Sabre 50-577
North American Aviation YF-86D Sabre 50-577. (U.S. Air Force)

22 December 1949: North American Aviation, Inc., test pilot George S. Welch made the first flight of the YF-86D Sabre, 50-577 (c/n 164-1, at Edwards Air Force Base, in the high desert of southern California.

Based on the F-86A day fighter, the F-86D (originally designated YF-95) was a radar-equipped, rocket-armed, all-weather interceptor. Its first flight took place only nine years after the first flight of North American’s prototype NA-73X, which would become the famous P-51 Mustang fighter of World War II. This was an amazing jump in technology in just a few years.

The interceptor was intended to be an improved variant of the F-86A Sabre day fighter. During development, though, so many changes became necessary that the F-86D shared only about 25% of its parts of the F-86A. Essentially an new airplane, the Air Force assigned it the designation YF-95. It would revert to the F-86D designation before it actually flew.

North American Aviation YF-86D Sabre 50-577, the first of two service test aircraft, at the North American Aviation flight line, Los Angeles International Airport. (North American Aviation)
North American Aviation YF-86D Sabre 50-577, the first of two service test aircraft, at the North American Aviation flight line, Los Angeles International Airport. (North American Aviation, Inc.)

The first YF-86D (still identified as YF-95) was rolled out at North American’s Inglewood plant in September 1949. In late November it was partially disassembled to be transported by truck to Edwards Air Force Base, about 120 miles (193 kilometers) away. The airplane was then reassembled and ground tested to prepare it for flight.

North American Aviation, Inc., F-86D-1-NA Sabre 50-456, the second production aircraft. (Ray Wagner Collection, San Diego Air & Space Museum Archives)
North American Aviation, Inc., F-86D-1-NA Sabre 50-456, s/n 165-2, the second production aircraft (Ray Wagner Collection, San Diego Air & Space Museum Archives)
North American Aviation, Inc., F-86D-1-NA Sabre 50-458, s/n 165-4. (Ray Wagner Collection, San Diego Air & Space Museum Archives)

The first two test aircraft carried no armament or fire control/radar system and retained the sliding canopy of the F-86A. This would be replaced with a hinged “clamshell” canopy in production models. The airplane was 40 feet, 3.1 inches (12.271 meters) long with a wingspan of 37 feet, 1 inch (11.294 meters) and overall height of 15 feet, 0 inches (4.572 meters). Its empty weight was 12,470 pounds (5,656 kilograms) and maximum takeoff weight was 18,483 pounds (8,384 kilograms).

The service test aircraft and early production airplanes were powered by a General Electric J47-GE-17 single-shaft axial-flow turbojet engine, producing 5,425 pounds of thrust (24.132 kilonewtons) at 7,950 r.p.m., or 7,500 pounds (33.362 kilonewtons) with afterburner. This engine was equipped with an electronic fuel control system which substantially reduced the pilot’s workload. The engine had a 12-stage compressor, 8 combustion chambers, and single-stage turbine. It was 226.0 inches (5.740 meters) long, 39.75 inches (1.010 meters) in diameters, and weighed 3,000 pounds (1,361 kilograms).

The first production aircraft, F-86D-1-NA Sabre 50-455 (manufacturer’s serial number 165-1) had a maximum speed of 614 knots (707 miles per hour/1,137 kilometers per hour) at Sea Level, and 539 knots (620 miles per hour/998 kilometers per hour)at 40,000 feet (12,192 meters). From a standing start, the interceptor could climb to 40,000 feet in 5 minutes, 54 seconds with a full combat load. The service ceiling was 54,000 feet (16,460 meters).

North American Aviation, Inc., F-86D-15-NA Sabre 50-574 (c/n 165-120), firing 2.75-inch FFAR rockets, circa 1950. (NASM)
A production North American Aviation F-86D-60-NA Sabre, 53-4061, firing a salvo of 2.75-inch FFAR rockets. (U.S. Air Force)

The F-86D Sabre carried no guns. Instead, its armament consisted of twenty-four 2.75-inch (70 millimeter) Mk 4 Folding Fin Aerial Rockets (FFAR) with explosive warheads, carried in a retractable tray in the airplane’s belly. A Hughes electronic fire control computer was used to calculate an interception path and determine the firing point for the unguided rockets.

The aircraft was so complex that the pilot training course was the longest of any aircraft in the U.S. Air Force inventory, including the Boeing B-47 Stratojet.

The single-seat F-86D Sabre was nearly 50 knots faster than the contemporary twin-engine Northrop F-89 Scorpion and Lockheed F-94 Starfire, both of which carried a two-man crew. North American Aviation built 2,504 F-86D Sabres, and these equipped nearly two-thirds of the Air Defense Command interceptor squadrons.

North American Aviation YF-86 Sabre 50-577, NACA 149. (NASA)
North American Aviation YF-86D Sabre 50-577, NACA 149, at the NACA Ames Research Center, Moffett Field, California. (NASA)

After the Air Force service test program was completed, 50-577 was transferred to the National Advisory Committee on Aeronautics (NACA) Ames Aeronautical Laboratory at Moffett Field, California, and designated NACA 149. It was used as a variable stability aircraft for flight testing various control configurations for feel, sensitivity and response.

NACA 149 remained at Ames from 26 June 1952 to 15 February 1960.

© 2018, Bryan R. Swopes