11

Material Safety Data Sheet
SOLVALUX 7-73
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY
Product Name : Solvalux 7-73
Product Type : Thinner
Supplier : Asian Paints (Middle East) L.L.C
P O Box 462, P.C. 133, Al Khuwair
Sultanate of Oman.
Telephone Number : 00-968-24596709
Fax Number : 00-968-24501531
2. COMPOSITION/INFORMATION ON INGREDIENTS :
Weight% CAS Number LEL Vol% ACGIH TLV-TWA
• Aromatic <60 1330-20-7 1.2 100 ppm

hydrocarbon
• Methoxy Propyl Acetate <60 108-65-6 1.5 Not known
3. HAZARDS IDENTIFICATION :
Human Health Hazards : Harmful by inhalation and in contact with skin. Irritating
To skin. Narcotic at high vapour pressure. Aspiration
Into the lungs may cause chemical pneumonitis. May
Impair fertility. Swallowing may cause headache, nausea,
vomiting, breathing difficulties and weakness. Possible
kidney damage may result from ingestion of large
quantities of material.
4. FIRST AID MEASURES :

General : Remove contaminated clothing.
First Aid - Inhalation : Remove to fresh air. If rapid recovery does not occur,
obtain medical attention.
First Aid - Skin : Remove contaminated clothing immediately. Wash skin
thoroughly with soap and water.
First Aid - Eye : Irrigate copiously with clean, fresh water for atleast 10
minutes, holding the eye lids apart and seek medical
advice.
First Aid - Ingestion : Do not induce vomiting. Obtain immediate medical
attention.
5. FIRE FIGHTING MEASURES :
Specific hazards : Fire will produce dense, black smoke. Inhalation of
decomposition products may cause serious health
hazards.
Extinguishing media : Water spray-mist, foam, dry chemical powder, carbon
dioxide, sand.
Unsuitable extinguishing media : Water in a jet.
... (2) ..
6. ACCIDENTAL RELEASE MEASURES :
Personal precautions : Avoid contact with skin and eyes. Do not breathe
vapour. Extinguish naked flames. Remove ignition
sources. Avoid sparks.
Personal protection : Wear PVC gloves, safety boots. Wear full face-piece
respirator with organic vapour canister NPF 400. In a
confined space, wear self-contained breathing apparatus
open circuit type NPF 2000.
Environmental precautions : Prevent contamination of soil and water.
Processing for Cleaning/
Collecting : Contain and collect spillage with non-combustible
absorbent materials, e.g., sand, earth or spill control
material and place in a container for disposal
according to local regulation.
7. HANDLING AND STORAGE:

Avoid prolonged or repeated contact with skin. Do not breathe vapour, spray/mists.
Extinguish any naked flames. Remove ignition sources. Avoid spark. Do not smoke.
Take precautionary measures against static discharges.
Handling temperature : Ambient

Storage : Keep container tightly closed and in a well ventilated
place. Keep away from direct sunlight and other sources
of heat or ignition. Do not smoke in storage areas.
Storage temperature : Ambient.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION :

Engineering Control measures : Use only in well ventilated areas.
Respiratory protection : When workers are facing concentrations above the
exposure limit they must use appropriate certified
respirators.
Hand protection : PVC gloves. Barrier creams may help to protect the
exposed areas of the skin.
Eye protection : Use safety eyewear designed to protect against splash
of products.
9. PHYSICAL AND CHEMICAL PROPERTIES :

Physical state : Liquid
Odour : Paraffinic
Safety related information : Value
Flash Point 25 - 30ºC
Ignition temperature > 350ºC
Boiling Point 137ºC (Based on Xylene)
Vapour Density (Vs. Air) Heavier
Evaporation Rate (Vs. n-Bu. Acetate) Slower
Density at 25ºC 0.90 – 0.92 gm/cc
Solubility in water In-soluble.
... (3) ..
10. STABILITY/REACTIVITY :
Stability : Stable under normal use conditions. Polymerised in
presence of oxygen.
Conditions to avoid : Heat, flames and sparks
Materials to avoid : Strong oxidizing agents and alkalies.
Hazardous decomposition : Carbon mono-oxide and/or carbon di-oxide.
Products
11. TOXICOLOGICAL INFORMATION :

Basis for assessment : This product was not tested but the information
given is based on the known toxicological data
of the constituents.
Acute toxicity - oral : LD 50 expected to be above 2000 mg/kg based on Xylene
Acute toxicity - dermal : LD 50 expected to be above 2000 mg/kg based on Xylene
Acute toxicity - inhalation : LC 50 expected to be > 5 mg/l
Eye irritation : The liquid splashed in the eyes may cause irritation.
Skin irritation : Not a skin sensitiser but prolonged contact with the
preparation may cause removal of natural fat from the
skin resulting to dermatitis.
12. ECOLOGICAL : Avoid contamination of earth, rivers, lakes or sewages

INFORMATION
Water contamination class : 2 (self classification)
13. DISPOSAL CONSIDERATIONS :
Precautions : Refer to Section 7

Waste disposal : Recover or recycle if possible. Otherwise incineration.
Container disposal : Allow the residue to dry and dispose of as scrap metal.
14. TRANSPORT INFORMATION :

UN Number : 1263
IMCO Class : 3.3
Page Number : 3149
Marine Pollutant : Yes
Proper shipping name : Thinner
... (4) .
15. REGULATORY INFORMATION :
• EC Classification : Flammable dangerous for the environment
Contains : Ethoxy Ethanol
• EC Risk phrases
R10 : Flammable.
R20/21 : Harmful by inhalation and in contact with skin.
R38 : Irritating to skin.
• EC Safety Phrases
S13/25/45/53 : Avoid contact with eyes.
16. DISCLAIMER :
This information is based on our current knowledge and is obtained from sources which we believe
are reliable. However, the information is provided without any warranty, express or implied,
regarding the correctness. This information is extended to describe the product for the purposes of
health, safety and environmental requirements only. The conditions or methods of handling,
storage, use or disposal of the product are beyond our control. For this and other reasons, we do not
assume responsibility and expressly disclaim liability for loss, damage connected with the handling,
storage, use or disposal of the product.
Version: 2 AUG 2022

11

Uploaded by

Copyright:

Available Formats

11

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

11

Uploaded by

Copyright:

Available Formats

Material Safety Data Sheet

• Aromatic <60 1330-20-7 1.2 100 ppm

4. FIRST AID MEASURES :

7. HANDLING AND STORAGE:

Handling temperature : Ambient

8. EXPOSURE CONTROLS/PERSONAL PROTECTION :

9. PHYSICAL AND CHEMICAL PROPERTIES :

11. TOXICOLOGICAL INFORMATION :

12. ECOLOGICAL : Avoid contamination of earth, rivers, lakes or sewages

13. DISPOSAL CONSIDERATIONS :

Precautions : Refer to Section 7

14. TRANSPORT INFORMATION :

Version: 2 AUG 2022

You might also like