When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number. "Right" and "Left" are determined from a position sitting on the seat and looking forward. GEHL Company reserves the right to make changes or improvements in the design or construction of any part of the unit.
When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number. "Right" and "Left" are determined from a position sitting on the seat and looking forward. GEHL Company reserves the right to make changes or improvements in the design or construction of any part of the unit.
When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number. "Right" and "Left" are determined from a position sitting on the seat and looking forward. GEHL Company reserves the right to make changes or improvements in the design or construction of any part of the unit.
When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number. "Right" and "Left" are determined from a position sitting on the seat and looking forward. GEHL Company reserves the right to make changes or improvements in the design or construction of any part of the unit.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PDF, TXT or read online from Scribd
Download as pdf or txt
You are on page 1of 32
Ht S60
LOADER
»
Z
<
al
2
0
0
a)
IT
Ww
Oj
SERVICE PARTS MANUALMr. Dealer:
When ordering service parts, specify the correct part
number, full description, quantity required, the unit
model number and serial number.
Numbers for this unit are stamped on a plate which is
located on the left Riser below the Cross Frame Support.
“Right” and “Left”are determined froma position sitting
‘on the seat and looking forward, From this position, the
Traction T-bar is the left-hand Control and the Lift/Tilt
‘T-bar is the right-hand Control.
GEHL Company reserves the right to make changes or
improvements in the design or construction of any part of
the unit without incurring the obligation to install such
changes on any unit previously delivered.
NOTE: common hardware, such as nuts, cap
screws, etc. are listed in the parts list but NOT
illustrated. Hardware listed, is for mounting
purposes and NOT included when the partis order-
ed for replacement. For the part numbers of
‘common hardware, refer to the attaching hardware
table located inside the back cover.
NOTE: | on original Tie replacement, Comp
ny policy prohibits the sale of replacement tires for
ail original GEHL machinery. Replacement Wheel
Sets are avaliable and tire size information iscalled-
‘out with the Whee! Sets to facilitate replacement tire
Selection. ALL REPLACEMENT TIRES MUST BE
PURCHASED LOCALLY.
‘Standard hardware torques appear in a chart at the end
of the manual.
Unless otherwise specified, all Cap Screws or Bolts are
Grade 5, cadmium or zine plated; Hexagon Nuts for
Grade 5 Cap Screws or Bolts are Grade B; Hexagon Nuts
for other Cap Screws or Bolts are Grade A.
‘The following abbreviations are used in this manual:
CB -Carriage Bolt
HHCS -Hexagon Head Cap Screw
CN -Castellated Nut
HLN — -Hexagon Lock Nut
HN -Hexagon Nut
LW -Lock Washer
PW -Plain Washer
NF -Natinal Fine (Thread)
LH -Left Hand
LD, — Inside Diameter
O.D, — -Outside Diameter
Sq. SquareTABLE OF CONTENTS
Page
- Inside Front Cover
223
45
Introduction ...
Decal Location «
Main Frame... :
Hydrostatic Drive Pump ldler «
Axle & Drive ve
Hydraulic Motor
Engine Controls .
Load Arms
Hydraulic Cylinders ...
Hydrostatie/ Hydrauii
Hydrostatic Transmission ..
Gear Pumps
Hydraulic System.
2-Spool Conteol Valve-
3.Spool (Auxiliary) Control Valve
Electrical System :
T-Bar Console & Controls...
Optional Auxiliary Hydraulics
Optional Attachments .
42° Utility Bucket
36" Utility Bucket 02.2.2.
60” Light Materials Bucket
48" Light Materials Bucket
36" Manure Fork
42" Manure Fork
42" Light Materials Bucket
36" Pallet Fork...
Accessories. ...e.ssce
Welt On Grapple
Light Kit
Numerical Index . fees Dies ce
Torque Specifications ........ eeeereeeees fe : SOIT inside Baek ‘Cover
Attaching Hardware Table <2... : : : fiiteetssessess Inside Back Cover